About The Benefits of Concrete Leveling

Concrete Leveling Contractors Broadview Heights involves taking a sunken concrete slab and raising it back to its original position. This can be done in several ways, including foam leveling or mudjacking.

Mudjacking involves pumping a mud-like mixture under the concrete slab to lift it back to its original height. Another option is poly leveling, which uses small holes to inject a polyurethane foam that expands to raise the concrete.

Cost

Uneven concrete is not only unsightly, it can also be dangerous for pedestrians and vehicles. Concrete leveling repairs the problem by lifting the slab and making it a safe surface to walk on again. It is a much less expensive option than having to replace the concrete.

The cost of concrete leveling can vary, depending on the method used and the area being repaired. Mudjacking, also known as slabjacking, involves drilling small holes into the concrete and pumping a limestone slurry underneath it to lift it. It can be used to raise any type of slab, including load-bearing ones.

Poly leveling, on the other hand, involves pumping foam under a concrete slab to give it a stronger foundation to sit on. This is a durable solution that lasts up to a decade. It is best for areas that are not load-bearing. It is also more expensive than mudjacking. Concrete leveling costs typically range from $1 to $5 per square foot.

Time

Uneven concrete can be a major safety hazard for pedestrians, especially children and the elderly. This is because the uneven surfaces can cause them to trip and fall, leading to serious injuries. However, there is a way to prevent this from happening by having your concrete leveled by an expert.

This process involves drilling holes into sunken concrete and filling them with a material that will lift the slab back into place. There are several different methods for doing this, including mud jacking and polylevel. The former uses a mixture of cement and soil to raise the slab, while the latter uses polyurethane foam to do the same thing.

The process of leveling concrete is not only safe for pedestrians but also saves you money in the long run. It is less expensive than replacing concrete, and it can be done in just a few hours. Moreover, it can be done on any surface, including driveways, sidewalks, patios, and pool decks.

Safety

Concrete leveling is a great way to fix sunken and uneven concrete slabs. It’s been around since the 1930s and works by injecting a material into the sunken concrete to lift it up. This method is far more effective than replacing the slab with new concrete, and also lasts longer.

It’s important to prepare the concrete before applying the leveling compound. This includes making sure there isn’t any structural damage and that the surface is clean. It’s also a good idea to check the moisture levels of the concrete. High levels of moisture can cause the leveling compound to degrade over time.

Before starting the application process, make sure all tools are prepared and the bag of concrete leveler is dry. Keep the bag indoors and away from extreme temperatures. A drill-mounted paddle is recommended for mixing the product, and a bucket with a capacity of 5 gallons should be used. The mixture should be mixed to a thin consistency.

Preparation

The concrete leveling cement must be mixed well to achieve a workable consistency. You can use a standard concrete mix, but self-leveling compound is specifically formulated with the correct flow and requires a special primer (such as TEC Multipurpose Primer).

After priming, you should sweep the floor surface to remove dirt and debris. Remove any oil stains using a commercial concrete oil-stain remover. A concrete grinder is useful for scrubbing away stains and ridges that a broom cannot reach.

Unlike slab replacement, concrete leveling addresses the underlying cause of sinking slabs by filling the voids with polyurethane foam. It also costs less than replacing the slab and can increase your property value. However, the process can be complicated and may require a permit. You should hire a qualified professional with the right licenses and insurance coverage for the job. A-1 Concrete Leveling has over 30 years of experience raising sunken concrete slabs in residential, commercial and industrial locations.